Vanning.com logo
Boxdin
Site Navigation


Advertisements
Recent Posts
extra dash plaque?
by newkirkinc1 - October 27th 2020 6:42 am
Replacing OEM steering Coupler with U joint !!!! PICS!!!
by wrcsixeight - October 27th 2020 3:21 am
A dissertation on G-Series 2WD Lift Kits (Front Only)
by HeliGuy93 - October 26th 2020 10:57 pm
1986 chevy G-20 short bed ,Florida
by BudVanBeer1 - October 26th 2020 9:58 pm
Will it fit ?
by Clayton73 - October 26th 2020 9:42 pm
Featured Links
Vanning.Com is a an authorized Amsoil Dealer


Previous Thread
Next Thread
Print Thread
Rate Thread
Van keeps cutting off
#759934 April 29th 2020 3:41 pm
Joined: Dec 2002
Posts: 5,259
Blendor Of Fine Schnapps
OP Offline
Blendor Of Fine Schnapps
Joined: Dec 2002
Posts: 5,259
I have a, I have a 1999 Dodge Ram 1500 kid keeps cutting off when I get up raise the hood check on the wiring harness on the ACM or dacm itself and it will start back up again I have replaced the ECM four times the wiring harness once and it still keeps doing it does anybody have any ideas thank you


starwars
tom wyckoff
interstellar space truckers

[Linked Image]

I, not events, have the power to make me happy or unhappy today. I can choose which it shall be. Yesterday is dead, tomorrow hasn't arrived yet. I have just one day, today, and I'm going to be happy in it. Groucho Marx

Re: Van keeps cutting off
starwars #759956 April 29th 2020 11:33 pm
Joined: Apr 2010
Posts: 2,746
W
veteran
Offline
veteran
W
Joined: Apr 2010
Posts: 2,746
Does it work fine for a while with a new ECM, then the stalling issue crop up again a few months later?

The weight of the wire bundles leading to ECM/PCM must not hang on the connector itself or they will break the solder joints where the pin attach to the circuit board leading to intermittent issues.

Get some of this:
https://www.ebay.com/itm/Caig-DeoxIT-Perfect-Straw-D5S-6P-142g-5-solution-spray-can/401839854325?hash=item5d8f8592f5:g:1UQAAOSwInxXMo0J

No other electrical contact cleaner can compare, but they are good for flushing out old crusty dielectric grease before using the $$ DeoXit d5. Its not going to fix broken solder joints, but in many ways it does seem to work as magic electric juice

Follow the black cable from battery (-) to firewall and to engine block. INsepct, remove wirebrush shiny and reattach.

Your issues could be fuel pump or ignition coil related too

Re: Van keeps cutting off
wrcsixeight #760210 May 04th 2020 1:56 pm
Joined: Dec 2002
Posts: 5,259
Blendor Of Fine Schnapps
OP Offline
Blendor Of Fine Schnapps
Joined: Dec 2002
Posts: 5,259
When it cuts off all gauges don't work and the mileage reading says no bus


starwars
tom wyckoff
interstellar space truckers

[Linked Image]

I, not events, have the power to make me happy or unhappy today. I can choose which it shall be. Yesterday is dead, tomorrow hasn't arrived yet. I have just one day, today, and I'm going to be happy in it. Groucho Marx

Re: Van keeps cutting off
starwars #762368 June 16th 2020 5:49 am
Joined: Aug 2005
Posts: 20,782
Likes: 4
N
Supreme Master
Offline
Supreme Master
N
Joined: Aug 2005
Posts: 20,782
Likes: 4
Tom...under the hood on the rad support is the fuse box that holds all the relays and such. They are notorious for getting corrosion build-up inside. It's called the TIPM (Totally Integrated Power Module). That may be your issue since you're losing all power.

"The Totally Integrated Power Module (TIPM) is the gateway or distribution box for nearly the entire electrical system in late model Chrysler products. Its main purpose is to take the commands from various switches and other modules and send those commands in the form of voltage or ground to wherever it needs to go."---from Google


Nate Breece
--------------
1993 Chevy G20
2012 Hyundai Santa Fe
Re: Van keeps cutting off
NateB #762770 June 25th 2020 7:14 am
Joined: Dec 2002
Posts: 5,259
Blendor Of Fine Schnapps
OP Offline
Blendor Of Fine Schnapps
Joined: Dec 2002
Posts: 5,259
Thanks nate couple weeks ago we added extra ground wire and it ran great I put it out 600 miles on it and then the weather started getting warmer and when the weather started getting warmer it started cutting off again but I will check that fuse box to make sure that they are not corroded and when I get hot I'm sure they expand or something thanks for replying


starwars
tom wyckoff
interstellar space truckers

[Linked Image]

I, not events, have the power to make me happy or unhappy today. I can choose which it shall be. Yesterday is dead, tomorrow hasn't arrived yet. I have just one day, today, and I'm going to be happy in it. Groucho Marx

Re: Van keeps cutting off
starwars #764043 July 27th 2020 8:53 am
Joined: Dec 2002
Posts: 5,259
Blendor Of Fine Schnapps
OP Offline
Blendor Of Fine Schnapps
Joined: Dec 2002
Posts: 5,259
When the van quits running all gauges go to zero but there's still power to lights and radio


starwars
tom wyckoff
interstellar space truckers

[Linked Image]

I, not events, have the power to make me happy or unhappy today. I can choose which it shall be. Yesterday is dead, tomorrow hasn't arrived yet. I have just one day, today, and I'm going to be happy in it. Groucho Marx


Moderated by  Astro, Ram4ever 

Link Copied to Clipboard
Donate


discovery
Who's Online Now
0 members (), 4 guests, and 1 robot.
Key: Admin, Global Mod, Mod
Newest Members
HeliGuy93, natanic, stereo001, gumthps, Okibonoe
11663 Registered Users
Top Posters (30 Days)
SDMickey 163
frscke1 52
NateB 26
NEmery 23
Forum Statistics
Forums68
Topics38,185
Posts537,096
Members11,663
Most Online177
May 8th, 2013

Powered by UBB.threads™ PHP Forum Software 7.7.4