Vanning.com logo
Boxdin
Site Navigation


Advertisements
Recent Posts
Crazy mods
by Wedgy - March 28th 2024 7:24 am
Good day
by SDMickey - March 27th 2024 10:55 pm
Lew Greger
by MufflerMan Mike - March 27th 2024 5:15 pm
1987 G20 Gypsy
by SDMickey - March 25th 2024 9:39 pm
Featured Links


Previous Thread
Next Thread
Print Thread
Rate Thread
Page 1 of 2 1 2
New game: "WHAT THE HELL IS LEAKING?"
#728094 September 21st 2017 7:59 pm
Joined: Aug 2013
Posts: 172
Puzzele Offline OP
member
OP Offline
member
Joined: Aug 2013
Posts: 172
Help! I've got a new game. I call it, "WHAT THE HELL IS LEAKING?"

I'm attaching some photos. I THINK it is transmission fluid. However, this is the part that CONFUSES me. I have JUST checked the transmission fluid for the first time in about 2 years... The transmission fluid is 100% FULL. In fact, now that I FINALLY replaced the dipstick, it appears there is even a bit more transmission fluid than necessary. The van sits about 98% of the time... so these leaks occur over the past 2 years while sitting and NOT running.. BUT again... the transmission fluid is 100% FULL even with these leaks since I JUST checked.

Personally.. I do NOT really care about the leaks.. I just don't want to drive the van with no fluid and cause damage.. but even with ALL these friggin' leaks, it seems all the fluids are full... even after about 2 years.

Any suggestions? Should I really care at this point?


[Linked Image]
[Linked Image]
[Linked Image]
[Linked Image]

Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728103 September 21st 2017 10:05 pm
Joined: Sep 2017
Posts: 95
Likes: 7
J
journeyman
Offline
journeyman
J
Joined: Sep 2017
Posts: 95
Likes: 7
What color is the fluid? Are you checking the trans fluid while it’s warm, in neutral, and on level ground?


Jason
2008 Ford E-250 4x4
1984 Chevy G20 5.3L/4L60E (SOLD)
Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728105 September 21st 2017 10:44 pm
Joined: Aug 2013
Posts: 172
Puzzele Offline OP
member
OP Offline
member
Joined: Aug 2013
Posts: 172
I checked the transmission fluid while warmed up and still running on level ground and in park.

As for the color... the floor is so dirty that I just put a white floor tile underneath. I will wait until it drips to see the color... but I checked ALL the fluids including brake fluid, and everything is totally full.

Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728106 September 21st 2017 11:36 pm
Joined: Jun 2010
Posts: 18,286
Likes: 558
Offline
Joined: Jun 2010
Posts: 18,286
Likes: 558
rear main seal is going out


SUNSHINE VANS-VAN DIEGO
ADRENALIN BY THE GALLON & CHASIN RACIN
ONE FOR THE DIRT & ONE FOR THE STREETS
'93 CHEVY G30 454 4X4 SPORTVAN EXT 146" WB
'92 CHEVY G30 454 BEAUVILLE EXT 146" WB
Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728107 September 22nd 2017 12:06 am
Joined: Sep 2005
Posts: 9,855
Likes: 234
carpal tunnel
Offline
carpal tunnel
Joined: Sep 2005
Posts: 9,855
Likes: 234
I think you're right, it's most likely trans fluid. But that's not as much fluid as you may think.
It really only appears to be about three or four ounces at the very most. That stuff will spread out and look like more.

Is it showing up at three different spots under the van?

Last edited by CatFish; September 22nd 2017 12:07 am.
Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728109 September 22nd 2017 10:55 am
Joined: Aug 2001
Posts: 12,107
Likes: 37
Maniac
Offline
Maniac
Joined: Aug 2001
Posts: 12,107
Likes: 37
Did you check te trans fluid with the engine and transmision warm and idling in park? Transmision fluid must be checked with the engine running so the fluid pumpin the trans is pumping and drawing the fluid level in the sump down.


Windows- they're what make a van worth owning!
Re: New game: "WHAT THE HELL IS LEAKING?"
Reed #728110 September 22nd 2017 11:12 am
Joined: Aug 2013
Posts: 172
Puzzele Offline OP
member
OP Offline
member
Joined: Aug 2013
Posts: 172

Originally Posted by Reed
Did you check te trans fluid with the engine and transmision warm and idling in park? Transmision fluid must be checked with the engine running so the fluid pumpin the trans is pumping and drawing the fluid level in the sump down.


Yes. I checked the transmission fluid with the van warmed up, running and in park. Long story short, I finally was able to find an exact transmission dipstick so I made a point of FINALLY checking the transmission fluid. I had expected to see that the transmission fluid was a bit low (via the leaking) and it sitting for almost 2 years (other than a very rare drive)... but I discovered that the transmission fluid was 100% full. In fact, it looked like it was a bit over full but I didn't bother trying to drain any since its been running great for 2 years and I suspect there is a slooooooooooow leak.

Personally... I'm not terribly worried about the minor leaks as ALL the fluids that I can think of are completely full.. I'm just worried that some important fluid is missing which I need to fix/refill.

PS: I made this mistake with a 86 Vette and ended up blowing out the head gaskets via no coolant. Trust me, I'm a schmuck and know ZERO about auto mechanics... so don't wanna make the same mistake again.. particularly when I see that it is leaking from about 3 different places under the van as seen in the photos.

Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728114 September 22nd 2017 1:07 pm
Joined: Aug 2001
Posts: 12,107
Likes: 37
Maniac
Offline
Maniac
Joined: Aug 2001
Posts: 12,107
Likes: 37
The only mistake was buying a Corvette. Your old Ford is totally durable. The 351 in my 89 E-150 has been overheated at least three times and (due to various oil leaks) been run on the highway for long periods with only 1-2 quarts of oil in the motor and it is still going strong. If your transmission is over full then the leaks could very well be excess fluid leaking past a seal point. Could be the output shaft seal, the disptick tube seal, the gear sleector shaft seal, a loose cooler line fitting, or, worst case, a worn front main seal. Front seal is the worst because you have to pull the trans to replace a $2 part.


Windows- they're what make a van worth owning!
Re: New game: "WHAT THE HELL IS LEAKING?"
Puzzele #728115 September 22nd 2017 1:54 pm
Joined: Aug 2013
Posts: 172
Puzzele Offline OP
member
OP Offline
member
Joined: Aug 2013
Posts: 172
As for there being too much transmission fluid, that is possible... I only just discovered it now that I finally found a replacement dipstick and know how much fluid is in it, BUT.... even IF there is too much fluid, I don't think it would cause it to leak just SITTING in my garage.. It is NOT running.. Right?

(Remember... I'm a schmuck when it comes to auto mechanics so I'm genuinely asking because I don't know).

Thanks in advance for your input. smile


Page 1 of 2 1 2

Moderated by  Astro 

Link Copied to Clipboard
Donate


Upcoming Events
discovery
Who's Online Now
1 members (Wedgy), 20 guests, and 9 robots.
Key: Admin, Global Mod, Mod
Newest Members
TheDrunkenGunsmith, Jac, LOVclassics, ZenMuffin, Milkman530
12724 Registered Users
Top Posters (30 Days)
SDMickey 130
CatFish 28
frscke1 28
Wedgy 21
Forum Statistics
Forums68
Topics35,747
Posts537,897
Members12,724
Most Online177
May 8th, 2013

Powered by UBB.threads™ PHP Forum Software 7.7.4